自然科学版 英文版
自然科学版 英文版
自然科学版 英文版

您目前所在的位置:首页 - 期刊简介 - 详细页面

中南大学学报(自然科学版)

Journal of Central South University

第31卷    第1期    总第131期    2000年2月

[PDF全文下载]    [Flash在线阅读]

    

文章编号:1004-0609(2000)01-0089-03
Al-Si过共晶合金中初生硅的溶解动力学
张     蓉,曹秋芳,庞述先,刘     林

(西北工业大学物理系,西安710072)

摘 要: 以扩散为模型,并考虑界面反应对初生相溶解过程的影响,建立了初生相在过热熔体中的溶解动力学模型。同时以Al-18%Si(质量分数)合金为对象,在1100 ℃过热情况下,对该模型进行了验证,结果表明:该模型基本上能反应该条件下初生硅的溶解特性。

 

关键字: 过共晶Al-Si合金;初生相;溶解动力学

Dissolution kinetics of primary silicon for hypereutectic Al-Si alloy
ZHANG Rong, CAO Qiu-fang, PANG Shu-xian, LIU Lin

Department of Applied Physics, Northwestern Polytechnical University, Xi'an 710072, P.R.China

Abstract:As well known, coarse primary silicon phase in Al-Si hypereutectic alloy dentsits mechanical properties, thus limits the application of this alloy. In addition, it has been found that primary silicon in Al-Si hypereutectic alloys was of higher chemical stability in the melt, and its dissolution behavior had directly influence on the freezing microstructure and on the mechanical properties of the alloy. From above, investigating on dissolution character for primary silicon is very emergent. Therefore, the dissolution process of primary silicon particles in Al-18%Si (mass fraction) alloy was studied both by melt overheating experiment and by theoretical analysis, and a dissolution model of primary silicon in the melt was established based on the atomic diffusion and taken account of interface reaction; the results show that the theoretic curve agrees with the experiment one at overheating temperature of 1100 ℃.

 

Key words: hypereutectic Al-Si alloy; primary phases; dissolution kinetics

中南大学学报(自然科学版)
  ISSN 1672-7207
CN 43-1426/N
ZDXZAC
中南大学学报(英文版)
  ISSN 2095-2899
CN 43-1516/TB
JCSTFT
版权所有:《中南大学学报(自然科学版、英文版)》编辑部
地 址:湖南省长沙市中南大学 邮编: 410083
电 话: 0731-88879765 传真: 0731-88877727
电子邮箱:zngdxb@csu.edu.cn 湘ICP备09001153号